Effect of oil viscosity on the flow structure and pressure gradient in horizontal oil-water flow

N. Yusuf, Y. Al-Wahaibi, T. Al-Wahaibi, A. Al-Ajmi, A. S. Olawale, I. A. Mohammed

Research output: Contribution to journalArticle

28 Citations (Scopus)

Abstract

The flow patterns and pressure gradient of immiscible liquids are still subject of immense research interest. This is partly because fluids with different properties exhibit different flow behaviours in different pipe's configurations under different operating conditions. In this study, a combination of oil-water properties (σ= 20.1. mN/m) not previously reported was used in a 25.4. mm acrylic pipe. Experimental data of flow patterns, pressure gradient and phase inversion in horizontal oil-water flow are presented and analyzed together with comprehensive comments. The effect of oil viscosity on flow structure was assessed by comparing the present work data with those of Angeli and Hewitt (2000) and Raj et al. (2005). The comparison revealed several important findings. For example, the water velocity required to initiate the transition to non-stratified flow at low oil velocities increased as the oil viscosity increased while it decreased at higher oil velocities. The formation of bubbly and annular flows and the extent of dual continuous region were found to increase as the oil-water viscosity ratio increased. Dispersed oil in water appeared earlier when oil viscosity decreased.The effect of oil viscosity on pressure gradient was also investigated by comparing the results with Angeli and Hewitt (1998) and Chakrabarti et al. (2005). One of the main findings is the large difference between the pressure gradient results which is attributed to the difference in oil viscosity. The differences between the results become bigger at higher oil velocities. The largest difference in pressure values was observed in flow region where oil is the continuous phase. On the contrary, for dispersed oil in water (Do/w), the pressure gradient values observed at the same conditions are approximately the same. A simple correlation was developed to predict the pressure gradient in this regime. The correlation was validated using new experimental data.Finally, the effect of oil viscosity on pressure gradient prediction was investigated using the two flow model for stratified flow and the homogenous model for oil dispersed in water. Both models showed better prediction for the low oil viscosities.

Original languageEnglish
Pages (from-to)1019-1030
Number of pages12
JournalChemical Engineering Research and Design
Volume90
Issue number8
DOIs
Publication statusPublished - Aug 2012

Fingerprint

Flow structure
Pressure gradient
Oils
Viscosity
Water
Flow patterns
Pipe
Acrylics

Keywords

  • Flow pattern map
  • Flow pattern transition
  • Oil-water flow
  • Phase inversion
  • Pressure gradient

ASJC Scopus subject areas

  • Chemical Engineering(all)
  • Chemistry(all)

Cite this

Effect of oil viscosity on the flow structure and pressure gradient in horizontal oil-water flow. / Yusuf, N.; Al-Wahaibi, Y.; Al-Wahaibi, T.; Al-Ajmi, A.; Olawale, A. S.; Mohammed, I. A.

In: Chemical Engineering Research and Design, Vol. 90, No. 8, 08.2012, p. 1019-1030.

Research output: Contribution to journalArticle

@article{5364ebb5e171460a92b5ca0550a15ca0,
title = "Effect of oil viscosity on the flow structure and pressure gradient in horizontal oil-water flow",
abstract = "The flow patterns and pressure gradient of immiscible liquids are still subject of immense research interest. This is partly because fluids with different properties exhibit different flow behaviours in different pipe's configurations under different operating conditions. In this study, a combination of oil-water properties (σ= 20.1. mN/m) not previously reported was used in a 25.4. mm acrylic pipe. Experimental data of flow patterns, pressure gradient and phase inversion in horizontal oil-water flow are presented and analyzed together with comprehensive comments. The effect of oil viscosity on flow structure was assessed by comparing the present work data with those of Angeli and Hewitt (2000) and Raj et al. (2005). The comparison revealed several important findings. For example, the water velocity required to initiate the transition to non-stratified flow at low oil velocities increased as the oil viscosity increased while it decreased at higher oil velocities. The formation of bubbly and annular flows and the extent of dual continuous region were found to increase as the oil-water viscosity ratio increased. Dispersed oil in water appeared earlier when oil viscosity decreased.The effect of oil viscosity on pressure gradient was also investigated by comparing the results with Angeli and Hewitt (1998) and Chakrabarti et al. (2005). One of the main findings is the large difference between the pressure gradient results which is attributed to the difference in oil viscosity. The differences between the results become bigger at higher oil velocities. The largest difference in pressure values was observed in flow region where oil is the continuous phase. On the contrary, for dispersed oil in water (Do/w), the pressure gradient values observed at the same conditions are approximately the same. A simple correlation was developed to predict the pressure gradient in this regime. The correlation was validated using new experimental data.Finally, the effect of oil viscosity on pressure gradient prediction was investigated using the two flow model for stratified flow and the homogenous model for oil dispersed in water. Both models showed better prediction for the low oil viscosities.",
keywords = "Flow pattern map, Flow pattern transition, Oil-water flow, Phase inversion, Pressure gradient",
author = "N. Yusuf and Y. Al-Wahaibi and T. Al-Wahaibi and A. Al-Ajmi and Olawale, {A. S.} and Mohammed, {I. A.}",
year = "2012",
month = "8",
doi = "10.1016/j.cherd.2011.11.013",
language = "English",
volume = "90",
pages = "1019--1030",
journal = "Chemical Engineering Research and Design",
issn = "0263-8762",
publisher = "Institution of Chemical Engineers",
number = "8",

}

TY - JOUR

T1 - Effect of oil viscosity on the flow structure and pressure gradient in horizontal oil-water flow

AU - Yusuf, N.

AU - Al-Wahaibi, Y.

AU - Al-Wahaibi, T.

AU - Al-Ajmi, A.

AU - Olawale, A. S.

AU - Mohammed, I. A.

PY - 2012/8

Y1 - 2012/8

N2 - The flow patterns and pressure gradient of immiscible liquids are still subject of immense research interest. This is partly because fluids with different properties exhibit different flow behaviours in different pipe's configurations under different operating conditions. In this study, a combination of oil-water properties (σ= 20.1. mN/m) not previously reported was used in a 25.4. mm acrylic pipe. Experimental data of flow patterns, pressure gradient and phase inversion in horizontal oil-water flow are presented and analyzed together with comprehensive comments. The effect of oil viscosity on flow structure was assessed by comparing the present work data with those of Angeli and Hewitt (2000) and Raj et al. (2005). The comparison revealed several important findings. For example, the water velocity required to initiate the transition to non-stratified flow at low oil velocities increased as the oil viscosity increased while it decreased at higher oil velocities. The formation of bubbly and annular flows and the extent of dual continuous region were found to increase as the oil-water viscosity ratio increased. Dispersed oil in water appeared earlier when oil viscosity decreased.The effect of oil viscosity on pressure gradient was also investigated by comparing the results with Angeli and Hewitt (1998) and Chakrabarti et al. (2005). One of the main findings is the large difference between the pressure gradient results which is attributed to the difference in oil viscosity. The differences between the results become bigger at higher oil velocities. The largest difference in pressure values was observed in flow region where oil is the continuous phase. On the contrary, for dispersed oil in water (Do/w), the pressure gradient values observed at the same conditions are approximately the same. A simple correlation was developed to predict the pressure gradient in this regime. The correlation was validated using new experimental data.Finally, the effect of oil viscosity on pressure gradient prediction was investigated using the two flow model for stratified flow and the homogenous model for oil dispersed in water. Both models showed better prediction for the low oil viscosities.

AB - The flow patterns and pressure gradient of immiscible liquids are still subject of immense research interest. This is partly because fluids with different properties exhibit different flow behaviours in different pipe's configurations under different operating conditions. In this study, a combination of oil-water properties (σ= 20.1. mN/m) not previously reported was used in a 25.4. mm acrylic pipe. Experimental data of flow patterns, pressure gradient and phase inversion in horizontal oil-water flow are presented and analyzed together with comprehensive comments. The effect of oil viscosity on flow structure was assessed by comparing the present work data with those of Angeli and Hewitt (2000) and Raj et al. (2005). The comparison revealed several important findings. For example, the water velocity required to initiate the transition to non-stratified flow at low oil velocities increased as the oil viscosity increased while it decreased at higher oil velocities. The formation of bubbly and annular flows and the extent of dual continuous region were found to increase as the oil-water viscosity ratio increased. Dispersed oil in water appeared earlier when oil viscosity decreased.The effect of oil viscosity on pressure gradient was also investigated by comparing the results with Angeli and Hewitt (1998) and Chakrabarti et al. (2005). One of the main findings is the large difference between the pressure gradient results which is attributed to the difference in oil viscosity. The differences between the results become bigger at higher oil velocities. The largest difference in pressure values was observed in flow region where oil is the continuous phase. On the contrary, for dispersed oil in water (Do/w), the pressure gradient values observed at the same conditions are approximately the same. A simple correlation was developed to predict the pressure gradient in this regime. The correlation was validated using new experimental data.Finally, the effect of oil viscosity on pressure gradient prediction was investigated using the two flow model for stratified flow and the homogenous model for oil dispersed in water. Both models showed better prediction for the low oil viscosities.

KW - Flow pattern map

KW - Flow pattern transition

KW - Oil-water flow

KW - Phase inversion

KW - Pressure gradient

UR - http://www.scopus.com/inward/record.url?scp=84864499422&partnerID=8YFLogxK

UR - http://www.scopus.com/inward/citedby.url?scp=84864499422&partnerID=8YFLogxK

U2 - 10.1016/j.cherd.2011.11.013

DO - 10.1016/j.cherd.2011.11.013

M3 - Article

VL - 90

SP - 1019

EP - 1030

JO - Chemical Engineering Research and Design

JF - Chemical Engineering Research and Design

SN - 0263-8762

IS - 8

ER -